Performance Enhancement of Motorcycle Engines Using Lemongrass Oil-Based Fuel Additive

Pangga Urip Setio Budi, Ade Suhara, Agus Supriyanto, Dhea Intan Patya, Khoirudin Khoirudin, Rizki Aulia Nanda

Abstract


The increasing number of motor vehicles has led to higher fuel consumption, especially among two-wheeled vehicles, contributing to elevated emissions of hydrocarbon (HC) and carbon monoxide (CO). This study investigates the potential of lemongrass oil (LO) as natural additive to reduce exhaust emissions from RON 92 fuel. The LO was extracted via maceration and characterized by its physical properties, including density (0.893 g/mL), viscosity (5.30 mPa.s), and boiling point (222 °C), consistent with pure LO standards. The additive as then blended into RON 92 fuel in concentration of 10 mL, 15 mL, and 20 mL per 1000 mL of fuel to determine its optimal performance. Results showed that a 20 mL addition yielded the highest reduction in HC and CO emissions, respectively 49.76% and 46.24%. Furthermore, engine performance improved, with power increasing by 0.27 HP and torque by 0.21 Nm within an engine speed range of 5200-5700 rpm. These outcomes suggest that LO enhances combustion efficiency and reduces emissions. The findings highlight the potential of LO as an environmentally friendly fuel additive and supprt ongoing efforts to develop sustainable alternatives to conventional fossil fuels in Indonesia.

Full Text:

PDF

References


T. Jeyaseelan, P. Ekambaram, J. Subramanian et al., “A comprehensive review on the current trends, challenges and future propects for sustainable mobility,” Renew. Sustain. Energy Rev., vol. 157, no. 112073, pp. 1-18, Apr: 2022.

N. Szymlet, Ł. Rymaniak, and P. Lijewski, “Two-wheeled urban vehicle – a review of emissions test regulations and literature,” Energies., vol. 17, no. 3(586), pp. 1-20, Feb: 2024.

A. Racha, S. Pai, C. Samanta et al., “Sustainable fuel additives derived from renewable resources: promising strategies for a greener future,” ACS Omega., vol. 10, no. 19, pp. 19256-19282, May: 2025.

J. Zhang, Y. Wang, V. L. Muldoon et al., “Crude glycerol and glycerol as fuels and fuel additives in combustion applications,” Renew. Sustain. Energy Rev., vol. 159, no. 112206, pp. 1-22, May: 2022.

Musyaroh, W. Wijayanti, and M. N. Sasongko, “The effect of sweet orange peel addition into premium gasoline on fuel consumption and flue gas emissions,” IOP Conf. Ser.: Mater. Sci. Eng., vol. 1034, no. 012038, pp. 1-9, Feb: 2021.

M. A. Asokan, S. S. Prabu, S. Prathiba et al., “Emission and performance behaviour of blends of diesel/lemongrass oil in DI diesel engine,” Mater. Toda Proc., vol. 46, no. 17, pp. 8080-8085, Apr: 2021.

A. Siswanto and W. Ruslan, “Pengaruh penambahan zat aditif toluena pada bahan bakar premium terhadap performa vespa sprint 150 3V,” JSA, vol. 2, no.9, pp. 1604-1616, Sep: 2021.

M. S. Rusli, H. Setiapraja, E. Agustian et al., “Effect of the addition of essential oils-based bio-additive on biodiesel B30 performance during durability and fiels tests,” IOP Conf.Ser.: Earth Environ. Sci., vol. 1354, no. 012026, pp. 1-11, Jun: 2024.

G. Singh, S. Sharma, j. Singh et al., “Optimization of performance, combustion and emission characteristics of acetylene aspirated diesel engine with osygenated fuels: an experimental approach,” Energy Rep., vol. 7, no. 1, pp. 1857-1874, Nov: 2021.

I. D. Sahputra, Zulfadli, L. Hanum, “Ekstraksi minyak atsiri dari daging buah pala (myristica fragrans houtt) dengan metode distilasi air-uap,” JIMPK, vol. 8, no. 2, pp. 58-65, Dec: 2024.

E. Koswara, H. Sonawan, N. N. Suryaman, “Improving freshwater yield from simple seawater distilation dispensers through condenser pipe modifications,” AEJ, vol. 14, no. 3, pp. 191-196, Sep: 2024.

S. O. Okpo and I. Edeh, “A comprehensive review on lemongrass (cymbopogon citratus) oil extraction and its applications,” EPRA Int. J. Res. Dev., vol. 8, no. 4, pp. 258-273, Apr: 2023.

S. P. Bangar, W. S. Whiteside, F. Ozogul et al., “Development of starch-based films reinforced with cellulosic nanocrystals and essential oil to extend the shelf life of red grapes,” Food Biosci., vol. 47, no. 101621, pp. 1-10, Jun: 2022.

W. D. S. Martins, J. S. F. D. Araujo, B. F. Feitosa et al., “Lemongrass (cymbopogon citratus DC. Stapf) essential oil micropaticles: development, characterization, and antioxidant potential,” Food Chem., vol. 355, no. 129644, pp. 1-7, Sep: 2021.

T. Sufin dan E. D. Daryono, “Pengaruh suhu dan konsentrasi minyak atsiri sereh terhadap sifat fisik minyak jelantah sebagai bahan bakar pengganti biodiesel,” JIP, vol. 13, no. 2, pp. 141-146, Nov: 2024.

T. Chaudhary, C. Varshney, A. Khan et al., “Pharmacological potential of lemongrass oil: a systematic review and meta analysis,” Biochem. Cell. Arch., vol. 24, no. 1, pp. 587-593, Apr: 2024.

K. Kolla, P. Periyasamy, M. Prabhahar et al., “Effect of three and five holes nozzle on thermal efficiency and emission characters of DI-CI diesel engine with lemongrass biodiesel as alternate fuel,” Therm. Sci., vol. 26, no. 2, pp. 1197-1205, Feb: 2022.

B. Ashaq, K. Rasool, S. Habib et al., “ Insights into chemistry, extraction and industrial application of lemon grass essential oil-a review of recent advances,” Food. Chem. X., vol. 22, no. 101521, pp. 1-18, Jun: 2024.

F. Benoudjit, I. Hamoudi, A. Aboulouz, “Extraction and characterization of essential oil and hydrolate obtained from an algerian lemongrass (cymbopogon citratus),” Alger. J. Environ. Sci. Technol., vol. 8, no.1, pp. 2256-2263, Mar: 2022.

N. Fitri, R. Riza, M. K. Akbari et al., “Identification of citronella oil fractions as efficient bio-additive for diesel engine fuel,” Designs, vol. 6, no. 1, pp. 1-13, Feb: 2022.

K. Tsitsilonis and G. Theotokatos, “A novel method for in-cylinder pressure prediction using the engine instantaneous crankshaft torque,” Proc. Inst. Mech. Eng. Pt. M J. Eng. Marit. Environ., vol. 236, no. 1, pp. 131-149, Feb: 2022.

T. Jia, X. Zhang, Y. Liu et al., “A comprehensive review of the thermal oxidation stability of jet fuels,” Chem. Eng. Sci., vol. 229, no. 116157, pp. 1-23, Jan: 2021.

Z. Liang, Z. Yu, H. Liu et al., “Co,bustion and emission characteristics of a compression ignition engine burning a wide range of conventional hydrocarbon and alternative fuels,” Energy., vol. 250, no. 123717, pp. 1-13, Jul: 2022.




DOI: https://doi.org/10.31284/j.jmesi.2025.v5i2.7778

Refbacks

  • There are currently no refbacks.


Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

Published by:
Mechanical Engineering Department - Institut Teknologi Adhi Tama Surabaya

Editorial Address
Journal of Mechanical Engineering, Science, and Innovation is licensed under CC BY-NC 4.0